当前位置:首页>海珀新闻>新闻资讯>聚氨酯保温管的日常维护及注意事项

聚氨酯保温管的日常维护及注意事项

来源:http://www.sdhpgy.com 日期:2020-06-24 发布人:haipo
1、为了防止铸铁平板发生的变形,在吊装铸铁聚氨酯保温管平台时,要用四根同样长度的钢丝绳同时挂住铸铁平板上得四个起重孔,将铸铁平板平稳吊装在运输工具上。
1. In order to prevent the deformation of the cast-iron plate, when hoisting the cast-iron polyurethane insulation pipe platform, four steel wire ropes of the same length should be used to hang the four lifting holes on the cast-iron plate at the same time, and the cast-iron plate should be stably hoisted on the transportation tool.
2、将铸铁聚氨酯保温管平台支承点垫好、垫平,保证每个支撑点受力均匀,保证整个铸铁平板平稳。
2. The supporting points of cast iron polyurethane insulation pipe platform shall be well padded and leveled to ensure that each supporting point is evenly stressed and the whole cast iron plate is stable.
3、铸铁聚氨酯保温管平台安装时将铸铁平板的各个支撑点用调整垫铁垫好、垫实,由技术人员将铸铁平板调整至合格精度。
3. During the installation of cast iron polyurethane insulation pipe platform, each supporting point of cast iron plate shall be padded with adjusting pad iron, which shall be adjusted to qualified precision by professional technicians.
4、铸铁聚氨酯保温管平台使用时要轻拿轻放工件,不要在铸铁平板上挪动比较粗糙的工件,以免对铸铁平板工作面造成磕碰、划伤等损坏。
4. When using the cast-iron polyurethane insulation pipe platform, handle the workpiece gently, and do not move the rough workpiece on the cast-iron plate, so as to avoid damage to the working face of the cast-iron plate such as collision, scratch, etc.
5、为了防止铸铁聚氨酯保温管平台整体变形,使用完毕后,要将工件从铸铁平板上拿下来,避免工件长时间对铸铁平板重压造成铸铁平板的变形。
5. In order to prevent the integral deformation of the cast iron polyurethane insulation pipe platform, the workpiece should be removed from the cast iron plate after use, so as to avoid the deformation of the cast iron plate caused by the heavy pressing of the cast iron plate for a long time.
6、铸铁聚氨酯保温管平台不用时要及时将工作面洗净,然后涂上一层防锈油,并用防锈纸盖上,用铸铁平板的外包装将铸铁平板盖好,以防止平时不注意造成对铸铁平板工作面的损伤。
6. When the cast iron polyurethane insulation pipe platform is not in use, the working surface shall be cleaned in time, then coated with a layer of antirust oil, covered with antirust paper, and covered with the outer package of the cast iron plate, so as to prevent the damage to the working surface of the cast iron plate caused by carelessness at ordinary times.
7、铸铁聚氨酯保温管平台应安装在通风、干燥的环境中,并远离热源、有腐蚀的气体、有腐蚀的液体。
7. Cast iron polyurethane insulation pipe platform shall be installed in a ventilated and dry environment, and away from heat source, corrosive gas and corrosive liquid.
8、铸铁聚氨酯保温管平台按国家标准实行定期周检,检定周期根据具体情况可为6-12个月。包装:铁板包装和木制包装两种形式,平台表表用塑料膜封装,这种包装适于平板内陆运输,并有良好的防潮、防震、防锈和防野蛮装卸等保护平板的措施,以确保安全运抵现场。
8. Cast iron polyurethane insulation pipe platform shall be subject to periodic weekly inspection according to national standards, and the verification period can be 6-12 months according to specific conditions. Packaging: two forms of iron plate packaging and wooden packaging. The surface of the platform is sealed with plastic film. This packaging is suitable for inland transportation of the flat plate, and has good measures to protect the flat plate, such as moisture-proof, shockproof, rust proof and rough handling, so as to ensure safe transportation to the site.
聚氨酯保温管平台的运输:运输是保证平板不变形的一个重要环节,所以运输平板时要保证不超载,不超速,不疲劳驾驶, 不在天气恶劣的情况下运输。
Transportation of polyurethane insulation pipe platform: transportation is an important link to ensure that the flat plate does not deform, so when transporting the flat plate, it is necessary to ensure that it is not overloaded, overspeed, fatigue driving, or transported in bad weather.
使用注意事项:聚氨酯保温管平台在使用时要先进行安装调试。然后,把平板的工作面擦拭干净,在确认没有问题的情况下使用,使用过程中,要注意避免工件和平板的工作面有过激的碰撞,防止损坏平板的工作面;工件的重量更不可以超过平板的额定载荷,否则会造成工作质量降低,还有可能损坏平板的结构,甚至会造成平板变形,使之损坏,无法使用。
Precautions for use: polyurethane insulation pipe platform shall be installed and debugged before use. Then, wipe the working surface of the plate clean, and use it when there is no problem. During the use process, pay attention to avoid excessive collision between the workpiece and the working surface of the plate, and prevent damaging the working surface of the plate; The weight of the work piece shall not exceed the rated load of the flat plate, otherwise, the work quality will be reduced, the structure of the flat plate may be damaged, and even the flat plate will be deformed, so that it can not be used.

热销产品:   聚氨酯保温钢管厂家 济南保温管 黑夹克直埋式直缝钢管

版权所有:山东海珀管业科技发展有限公司   网站备案号:鲁ICP备18049456号 技术支持:济南诺商>
电话:13953119851 座机:0531—67819251 地址:山东省济南市长清区济南经济开发区南园金轮路9017号 

网址:http://www.sdhpgy.com 流量统计:  

【本站图片均由网站所有方提供,部分图片来源于网络,如无意中侵犯了某媒体或个人的知识产权,请来信或来电告之,本网站将立即删除。】